亚运会注册

故障分析/Failure Analysis

卡特彼勒挖掘机维修C系列发动机故障代码表

发布时间:2016-07-13

燃油温度传感器或线路故障174-04         174-04            Fuel Temperature short to ground   

燃油温度传感器或线路故障16            626-05            2417-05            Ether Injection Control Solenoid open/short to +batt  

乙醚喷射控制电磁阀或线路故障626-06         2417-06            Ether Injection Control Solenoid short to ground   

乙醚喷射控制电磁阀或线路故障21            678-03            41-03            8 Volt DC Supply short to +batt   

8V直流电源故障678-04         41-04            8 Volt DC Supply short to ground   

8V直流电源故障620-03         262-03            5 Volt Sensor DC Power Supply short to +batt   

5V直流电源故障1079-03      620-04         262-04            5 Volt Sensor DC Power Supply short to ground   

5V直流电源故障1079-04    24      100-03        100-03            Engine Oil Pressure open/short to +batt   

机油压力传感器或线路故障100-04         100-04            Engine Oil Pressure short to ground   

机油压力传感器或线路故障100-10         100-10            Engine Oil Pressure abnormal rate of change   

机油压力更新率不正常25            102-03            102-03            Boost Pressure Sensor short to +batt   

增压压力传感器或线路故障102-04         102-04            Boost Pressure Sensor short to ground   

增压压力传感器或线路故障 102-10         102-10            Boost Pressure Sensor abnormal rate of change   

增压压力更新率不正常102-03         1785-03            Intake Manifold Pressure Sensor voltage above normal   

进气压力传感器电压高于正常值102-04         1785-04            Intake Manifold Pressure Sensor voltage below normal   

进气压力传感器电压低于正常102-10         1785-10            Intake Manifold Pressure Sensor abnormal rate of change   

进气压力更新率不正常26            108-03            274-03            Atmospheric Pressure open/short to +batt   

大气压力传感器或线路故障108-04         274-04            Atmospheric Pressure short to ground   

大气压力传感器或线路故障27            110-03            110-03            Engine Coolant Temperature open/short to +batt   

冷却液温度传感器或线路故障110-04         110-04            Engine Coolant Temperature short to ground   

冷却液温度传感器或线路产28            91-13            91-13            Throttle Position calibration required   

油门需要校准32            91-08            91-08            Throttle Position signal abnormal   

油门信号不正常34            190-08            190-08            Engine Speed signal abnormal   

发动机转速信号不正常723-08         342-08            Secondary Engine Speed signal abnormal   

备用发动机转速信号不正常35            190-15            E362 (1)            Engine Overspeed Warning   

发动机超速报警190-00         E362 (3)            Engine Overspeed Shutdown   

发动机超速停机37            94-03            94-03            Fuel Pressure open/short to +batt   

燃油压力传感器或线路故障94-04         94-04            Fuel Pressure short to ground   

燃油压力传感器或线路故障38            105-03            172-03            Intake Manifold Air Temp open/short to +batt   

进气温度传感器或线路故障105-04         172-04            Intake Manifold Air Temp short to ground   

进气温度传感器或线路故障42            637-13            261-13            Engine Timing calibration required   

发动机正时需校准46            100-17            E360 (1)            Low Engine Oil Pressure Warning   

机油压力低报警100-18         E360 (2)            Low Engine Oil Pressure Derate   

机油压力低降载100-01         E360 (3)            Low Engine Oil Pressure Shutdown   

机油压力低停机51            168-00            168-00            System Voltage high   

系统电压高168-01         168-01            System Voltage low   

系统电压低168-02         168-02            System Voltage intermittent/erratic   

系统电压不正常56            630-02            268-02            Check Programmable Parameters   

发动机参数设置需检查58            639-09            247-09            J1939 Data Link communications   

J1939数据链接故障61            110-15            E361 (1)            High Engine Coolant Temperature Warning  

冷却液温度高报警110-16         E361 (2)            High Engine Coolant Temperature Derate   

冷却液温度高降载110-00         E361 (3)            High Engine Coolant Temperature Shutdown   

冷却液温度高停机62            111-17            E2143 (1)            Low Engine Coolant Level Warning   

冷却液位低报警111-18         E2143 (2)            Low Engine Coolant Level Derate   

冷却液位低降载111-01         E2143 (3)            Low Engine Coolant Level Shutdown   

冷却液位低停机63            94-15            E096 (1)            High Fuel Pressure Warning   

燃油压力高报警64            1636-15            E539 (1)            High Inlet Air Temperature Warning   

进气温度高报警1636-00         E539 (3)            High Inlet Air Temperature Shutdown   

进气温度高停机65            174-15            E363 (1)            High Fuel Temperature Warning   

燃油温度高报警174-16         E363 (2)            High Fuel Temperature Derate   

燃油温度高降载174-00         E363 (3)            High Fuel Temperature Shutdown   

燃油温度高停机67            0441-15            E445 (1)            High Auxiliary Temperature Warning   

辅助温度高报警0441-16         E445 (2)            High Auxiliary Temperature Derate   

辅助温度高降载0441-00         E445 (3)            High Auxiliary Temperature Shutdown   

辅助温度高停机0441-03         1836-03            Auxiliary Temperature Sensor open/short to +batt   

辅助温度传感器或线路故障0441-04         1836-04            Auxiliary Temperature Sensor short to ground   

辅助温度传感器或线路故障68            1387-15            E443 (1)            High Auxiliary Pressure Warning   

辅助压力高报警1387-16         E443 (2)            High Auxiliary Pressure Derate   

辅助压力高降载1387-00         E443 (3)            High Auxiliary Pressure Shutdown   

辅助压力高停机1387-03         1835-03            Auxiliary Pressure Sensor open/short to +batt   

辅助压力传感器或线路故障1387-04         1835-04            Auxiliary Pressure Sensor short to ground   

辅助压力传感器或线路故障71            651-05            001-05            Cylinder #1 Injector open circuit   

1缸喷油器故障651-06         001-06            Cylinder #1 Injector short   

1缸喷油器故障72            652-05            002-05            Cylinder #2 Injector open circuit   

2缸喷油器故障652-06         002-06            Cylinder #2 Injector short   

2缸喷油器故障73            653-05            003-05            Cylinder #3 Injector open circuit    

3缸喷油器故障653-06         003-06            Cylinder #3 Injector short   

3缸喷油器故障74            654-05            004-05            Cylinder #4 Injector open circuit   

4缸喷油器故障654-06         004-06            Cylinder #4 Injector short   

4缸喷油器故障75            655-05            005-05            Cylinder #5 Injector open circuit   

5缸喷油器故障655-06         005-06            Cylinder #5 Injector short   

5缸喷油器故障76            656-05            006-05            Cylinder #6 Injector open circuit   

6缸喷油器故障656-06         006-06            Cylinder #6 Injector short

6缸喷油器故障

返回顶部

在线客服中心

0551-64536067

很高兴为您服务!

微信二维码