亚运会注册

故障分析/Failure Analysis

卡特彼勒C9挖掘机故障代码

发布时间:2017-10-20

故障码Component failure故障部件车辆1

112        Accelerator Pedal 1 Failure加速踏板1故障

113        Accelerator Pedal /Brake Plausibility加速踏板与制动踏板信号不可信

116        Main Clutch Signal Failure离合信号故障

117        Brake Signal Failure制动踏板故障

119        Terminal 15 Failure 15 端子故障

11C        Water in Fuel燃油滤清器储水器

211        Vehicle Speed Sensor Failure车速传感器故障

215        Cruise Control Buttons Irreversible巡航控制按扭不可逆故障

315        Cruise Control Buttons Reversible Failure巡航控制开关可逆故障车辆2(继电器/执行器)

125        Main Relay 2 Failure主继电器2失效

126        Battery Voltage Failure蓄电池电压故障

127        Engine Brake decompression Valve failure发动机制动失效

128        Main Relay 1-Short Circuit To Battery主继电器1与电池短路

129        Main Relay 3 Failure主继电器3故障

12A        Thermostarter Relay 1(Heater)发动机制动(主继电器4)故障

12B        Air Heater 1 Power Stage Failure空气加热器1 Power Stage 故障

12E        Pre-Post Heating Control System (Active)预加热控制系统故障

225        Main Relay failure (Interrupted Afterrun)主继电器失效(停机后中断)

228        Main Relay 1 (High Pressure Pump) Short to Ground主继电器1对地短路发动机1(温度和压力传感器)

131        Coolant Temperature Sensor failure冷却液温度传感器

132        Coolant Temperature Dynamic failure冷却液温度传感器动态故障

133        Boost Air Temperature Sensor failure进气温度传感器

134        Boost Pressure Sensor failure进气压力传感器

135        Fuel Temperature Sensor failure燃油温度传感器

136        Rail Pressure Sensor failure共轨压力传感器

137        Common Rail Pressure Limiting Valve failure共轨压力限压阀

138        Oil Pressure Sensor failure机油压力传感器

13A        Oil Temperature Sensor failure机油温度传感器

232        Coolant Temperature Test failure冷却液温度(监测)

236        Rail Pressure Sensor Offset Monitoring共轨压力传感器偏差监测

238        Oil Pressure too low机油压力过低

23A        Oil Temperature too high机油温度过高发动机2(转速传感器/执行器)

141        Crankshaft Speed Signal failure曲轴转速传感器

142        Engine runs with Camshaft Speed only只有凸轮轴传感器信号

143        Camshaft Speed Signal failure凸轮轴传感器

144        Offset between Camshaft and Crankshaft凸轮轴传感器和曲轴传感器信号偏差超出限值

149        Filter Heater failure燃油滤芯加热器故障

14A        Engine Compartment Start Button stuck发动机机舱启动按钮发卡

14D        Info: Engine Overspeed Protection提示:发动机超速保护

24A        Engine Compartment Stop Button stuck发动机机舱停止按钮发卡共轨系统燃油计量

152        Rail Pressure Positive Deviation High and High Fuel Flow Setpoint Value共轨压力正偏差过高和燃油流量设定值过高

153        Rail Pressure Negative Deviation too High on Minimum Metering共轨压力负偏差过高(最小流量)

154        Rail Pressure below Minimum Limit in Controlled Mode共轨压力低于最小极限

155        Rail Pressure above Maximum Limit in Controlled Mode共轨压力大于最大极限

156        Rail Pressure Drop Rate too High共轨燃油压力下降率太高

157        Setpoint of Rail Metering Unit not plausible in Overrun超速时共轨计量阀不真实

158        Fuel Flow Setpoint of Common Rail Metering Unit too low共轨计量装置燃油流量设置点过低

159        Common Rail Metering Unit Power Stage failure共轨油泵计量阀Power Stage 故障

259        Common Rail Metering Unit Power Stage Short to Battery共轨计量阀正极短路

359        Common Rail Metering Unit Power Stage Short to Ground共轨计量阀负极短路喷油器1

返回顶部

在线客服中心

0551-64536067

很高兴为您服务!

微信二维码